Product ID:SKASOL MB-T
MSDS Date:06/17/1997
FSC:6850
NIIN:00-RX9-8023
Status Code:A
MSDS Number: CJMGC

Emergency Phone: 800-424-9300

Info Phone: 800-424-9300

Preparer: JESSICA CORRIGAN

Cage: 0JRJ9

Telephone: 510-839-1000

Cage: 0JRJ9

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE SKIN IRRITATION.
CHRONIC: SAME AS ACUTE BUT MORE SEVERE.
Effects of Overexposure:INHALED-MAY CAUSE IRRITATION. SKIN OR
EYES-CAUSES SEVERE EYE BURNS. MAY CAUSE BLINDNESS. MAY BURN THE
SKIN. ABSORBED THROUGH SKIN-MAY CAUSE IRRITATION. SWALLOWED-MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NOT KNOWN.

First Aid:EYE-IMMEDIATELY FLUSH WITH PLENTY OF WATER, RAISING EYELIDS
OFTEN TO HELP IRRIGATION & CONTINUING FOR AT LEAST 30 MIN IS
IMPERATIVE. GET IMMEDIATE MEDICAL ASSISTANCE. SKIN-FLUSH WITHPLENTY
OF WATER, W ASH WITH SOAO & WATER. REMOVE CONTAMINATED CLOTHING.
GET MEDICAL ASSISTANCE IF IRRITATION PERSISTS. INHALED. REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION (PREFERABLY
MOUTHTO MOUTH . CALL A PHYSICIAN OR POISON CONTROL CENTER.
SWALLOWED-IF CONSCIOUS, GIVE PLENTY OF WATER & INDUCE VOMITING.
NEVER GIVE ANYTHING BY MOUTH TO ANUNCONSCIOUS PERSON. SEE A
PHYSICIAN.

Flash Point:NOT FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND RESPIRATORY
PROTECTION.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:DIKE AREA TO CONTAIN SPILL. COLLECT ALL
SPILLED MATERIAL. DO NOT FLUSH TO WASTE TREATMENT FACILITY OR WATER
COURSES.

Other Precautions:MEASURES DURING MAINTENANCE: CHEMICAL FEED PUMPS
SHOULD BE ROUTINELY WASHED OUT WITH WATER. PLASTIC TUBING AND
FITTINGS SHOULD BE FREQUENTLY INSPECTEDFOR LEAKS AND CLOGS. AS
WITHALL AUTOMATIC EUIPMENT , BE CERTAIN THAT THE POWER IS
DISCONNECTED BEFOREPERFORMING ANY ADJUSTMENTS OR REPAIRS.

Respiratory Protection:WHEN CONDITIONS REQUIRE IT, USE A RESPIRATOR
APPROVED BY NIOSH/MSHA WITH A DUST/MIST FILTER. RESPIRATORY
PROTECTION PROGRAMS MUST MEET OR EXCEED THE REQUIREMENTS OF TITLE
29 CFR 1910.134
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE SUFFICIENT TO MINIMIZE
EMPLOYEE EXPOSURE TO MIST BELOW OSHA PEL.
Protective Gloves:NITRILE, NEOPRENE OR NATURAL RUBBER.
Eye Protection:CLOSE FITTING CHEMICAL SAFETY GOGGLES WITH A FACE SHIELD
IF NEEDED.
Other Protective Equipment:RUBBER BOOTS WITH SAFETY TOES, RUBBER
APRONS, PLASTIC HARD HATS SHOULD BE USED WHEN NECESSARY TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:PROTECTIVE CLOTHING AND USE OF EQUIPMENT MUST
BE IN ACCORDANCE WITH TITLE 29 CFR SECTIONS 1910.132 AND 1910.133.
Supplemental Safety and Health
PROVIDE EMERGENCY EYE WASH STATIONS AND EMERGENCY SHOWER FACILITIES
NEAR USE AND HANDLING AREAS.

HCC:N1
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:30-35F
Vapor Density:<1(WATER)
Spec Gravity:0.95-1.05@23C
Solubility in Water:COMPLETE
Appearance and Odor:OFF WHITE DISPERSION, MUSTY ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIES, STRONG ACIDS.
Hazardous Decomposition Products:BURNING OF DRIED MATERIALS MAY PRODUCE
OXIDES OF CARBON AND NITROGEN AND CHLORINE COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF AS A PESTICIDE WASTE, IN ACCORDANCE
WITH STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:PROD HAS NOT BEEN TESTED FOR ECOTOXICITY. VENT: LIMS &
GUIDELINES. NEED FOR VENT SYS SHOULD BE EVALUATED BY PROFESSIONAL
INDUSTRIAL HYGIENIST, WHILE DESIGN OF SPECIFIC VENT SYS SHOULD BE
CONDUCTED BY PROFESSIONAL ENGINEER. APPEAR/ODOR: FORMED SHAPES
WITH OR W/OUT NON-WOVEN/VINYL FACINGS; NO SIGNIFICANT ODOR. VOC:
NOT APPLICABLE. HAZ DECOMP PRODS: MONOXIDE, CARBON PARTICLES,
FORMALDEHYDE & TRACES O F HYDROGEN CYANIDE. OTHER INFO: OUT &
SPRAYING MAY GENERATE AIRBORNE FIBER CONCS REQUIRING HIGHER LEVEL
OF RESP PROT. FOR EXPOS UP TO 50 TIMES ESTABLISHED EXPOS LIMS, USE
NIOSH APPRVD FULL-FACE RESP, RATED N99 OR HIGHER.

Transport Information:U.S. DOT SHIPPING CLASSIFICATION: NOT CLASSIFIED
AS HAZ MATL. TOXICOLOGICAL INFO: ADVERSE CLINICAL, FUNCTIONAL OR
RADIOGRAPHIC SIGNS OF EFTS OF EXPOS TO MMMFS (FIBER GLASS IS MMMF)
IN THESE WORKERS." IN ADDN TO REPORTING CURRENT RSLTS,
INVESTIGATORS CONCLUDED THAT "RSLTS OF INVESTIGATION ARE CONSISTENT
W/PREVIOUSLY REPORTED CROSS-SECTIONAL STUDIES THAT HAVE FAILED TO
FIND PERSUASIVE EVID OF RESP E FTS OF MFR OF MMMF." 1990 UPDATE OF
MORTALITY STUDY OF U.S. FIBER GLASS MFG WORKERS REPORTED SM BUT
STATISTICALLY SIGNIFICANT EXCESS IN RESP CANCER AMONG WORKERS. THIS
INCR, HOWEVER, COULD NOT BE ASSO C W/EXPOS TO FIBER GLASS (SARA
REGS)

SARA Title III Information:THERE ARE NO CHEMS IN THIS PROD REGULATED BY
SARA 313, CERCLA OR TSCA 12(B). TRANSPORT: BECAUSE NO RELATIONSHIP
FOUND BETWEEN DOSE RESPONSE OR LENGTH OF EMPLOYENT & INCR IN CANCER
RATES. STUDY HAS BEE N EXPANDED, WHILE CONTINUING TO MONITOR
WORKERS' CANCER RATES, TO IDENTIFY & EXAMINE POSS FACTORS (EG,
SMKNG) CONTRIBUTING TO INCR IN RESP CANCER. PREVIOUS CHRONIC ANIMAL
INHAL STUDIES HAVE NOT SHOWN ANY IRREVERSIBLE DISEASE EFTS RELATED
TO BLDG INSULATION FIBER GLASS EXPOS. FIVE PREVIOUS CHRONIC INHAL
STUDIES EXPOSING ANIMALS TO SPEC PURPOSE FIBER GLASS HAVE ALSO NOT
SHOWN ANY EVID OF DISEASE. CN TCT NEHC FOR MORE INFO .
Federal Regulatory Information:OSHA PELS IDENTIFIED IN INGRED SECTION
ARE BASED UPON REVISED PELS OF 1988. OSHA HAS BEEN CHALLENGED BY
COURTS TO PROVIDE MORE INFO ABOUT ITS UPDATE PROCESS. UNTIL THESE
ISSUES ARE RESOLVED, SCHULLER WILL CONTINUE TO LIST THESE PELS.
THIS PROD & ITS COPONENTS ARE LISTED ON TSCA SUBSTANCE INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65 - SUBSTANCES
KNOWN TO THE STATE TO CAUSE CANCER: GLASSWOOL FIBERS (AIRBORNE
PARTICLES OF RESPIRABLE SIZE).